Ford Expedition Car Audio
How to Remove, Replace, Install and Repair Car Stereo and Speakers
Car Stereo Repair
| Car Stereo Removal | FAQ | Shipping for Repair | Contact Us
   

Ford Expedition
Car Stereo Removal
with Automatic AC Controls

(Stereo Removal with Manual AC Controls Below)

   

Ford Car Stereo Repair
No Display

   

Ford Wire Harness

Factory Wire Harness Codes
Below

   

Aftermarket Wire Color Codes, Hook Up and Install

Factory Wire Connector Codes
Below

   
Speaker Phasing
Installing Aftermarket Speakers and Proper Hook-up
   
NO AUDIO
With aftermarket stereo installation?
   
Ford Expedition - Car Stereo Removal and Replacement
Car Stereo Repair | Car Stereo Removal | FAQ | Shipping for Repair | Contact Us
How to Remove Speakers, Replace and Install

Ford Expedition
How to Remove and Replace Car Stereo

(Manual AC Controls)

How to Remove Speakers, Replace and Install 1.1) Remove two screws from above gauges.
How to Remove Speakers, Replace and Install 2.1) Gently pull dash trim panel from dash.
How to Remove Speakers, Replace and Install 3.1) Release connectors from climate control area on dash panel.
How to Remove Speakers, Replace and Install 4.1) Left side of panel is tricky when removing from dash because of AC vent housing.
4.2) Tilt right side of dash panel up for access.
How to Remove Speakers, Replace and Install 5.1) Remove two bottom screws securing car stereo to dash.
5.2) Pull car stereo forward from dash.
How to Remove Speakers, Replace and Install 6.1) Disconnect antenna and release triggers on connectors to release.
6.2) Remove car stereo.
   
Ford Expedition - How to Remove and Replace Front Speaker
Car Stereo Repair | Car Stereo Removal | FAQ | Shipping for Repair | Contact Us
How to Install Speakers, Remove and Replace

Ford Expedition Front Speaker
Removal, Replacement and Installation

How to Remove Speaker, Replacing and Installing 1.1) Remove top edge of triangular panel above door panel by releasing clip.
How to Install Speakers, Remove and Replace 2.1) Pull panel up, releasing two clips into door panel.
How to Remove Speaker, Replacing and Installing 3.1) Remove exposed screw.
How to Install Speakers, Remove and Replace 4.1) Pry front edge of control panel up releasing clip, pull up releasing rear tongue clip.
4.2) Disconnect connectors.
How to Remove Speaker, Replacing and Installing 5.1) Remove exposed screw in control panel cavity.
How to Install Speakers, Remove and Replace 6.1) Pry cover off courtesy light.
How to Remove Speaker, Replacing and Installing 7.1) Remove exposed screw.
How to Install Speakers, Remove and Replace 8.1) Pry trim ring from around door open handle and feed trim ring into door panel.
How to Remove Speaker, Replacing and Installing 9.1) Lift door panel straight up, releasing hooks securing door panel.
9.2) Push door panel forward to feed door open handle through opening.
9.3) Disconnect courtesy light connector.
How to Install Speakers, Remove and Replace 10.1) Remove four screws securing 5" x 7" speaker to door.
10.2) Disconnect connector and remove speaker.
   
Ford Expedition - How to Remove and Replace Rear Speaker
Car Stereo Repair
| Car Stereo Removal | FAQ | Shipping for Repair | Contact Us
How to Remove Speaker, Replace and Install

Ford Expedition Rear Speaker
Removal, Replacement and Installation

How to Remove Speaker, Replace and Install 1.1) Pry front edge of control panel up releasing clip, pull up releasing rear tongue clip.
1.2) Disconnect connector.
How to Remove Speaker, Replace and Install 2.1) Pry trim ring from around door open handle and feed trim ring into door panel.
How to Remove Speaker, Replace and Install 3.1) Remove two screws along bottom edge of door panel.
How to Remove Speaker, Replace and Install 4.1) Lift door panel straight up, releasing hooks securing door panel.
4.2) Push door panel forward to feed door open handle through opening.
4.3) Remove four screws securing 5" x 7" speaker to door, disconnect connector.
   
Ford Expedition Rear Subwoofer, Amplifier and Speaker Remove and Replace
Car Stereo Repair
| Car Stereo Removal | FAQ | Shipping for Repair | Contact Us
Replacing Speakers, Installing and Removing

Ford Expedition
How to Remove and Replace
Rear Subwoofer Enclosure with Amplifier and Speaker

How to Remove Speakers, Replace and Install 1.1) Remove bottom panel along floor of Ford Expedition by lifting up this will release clips, set panel to side.
Replacing Speakers, Installing and Removing 2.1) Remove top panel along floor of Ford Expedition by pulling down at rear edge, this will release clips and set panel to side.
How to Remove Speakers, Replace and Install 3.1) Lift cover on rear seat belt exposing T50 Torx bolt and remove.
Replacing Speakers, Installing and Removing 4.1) Pull side panel from vehicle releasing clips and set panel to side.
How to Remove Speakers, Replace and Install 5.1) From rear passenger door, lift panel releasing clips and set to side.
Replacing Speakers, Installing and Removing 6.1) Lift cover on rear seat belt exposing nut and remove.
How to Remove Speakers, Replace and Install 7.1) Pull side panel from vehicle releasing clips and set panel to side.
Replacing Speakers, Installing and Removing 8.1) Lift cover on seat belt exposing T50 Torx bolt and remove.
How to Remove Speakers, Replace and Install 9.1) Release rear passenger seat and push forward.
9.2) Lift panel releasing first two or three clips without removing panel.
Replacing Speakers, Installing and Removing 10.1) Pull weather striping from door jam up side of vehicle.
How to Remove Speakers, Replace and Install 11.1) At back of vehicle, release rear seat belt mounting. Push center of anchor down about 1/4 inch, this releases anchor hold and will allow you to pry from opening.
11.2) Remove bolt from same area.
Replacing Speakers, Installing and Removing 12.1) Unscrew cargo net holders from side of vehicle.
How to Remove Speakers, Replace and Install 13.1) Lift edge of carpet to expose one screw along bottom of side panel.
Replacing Speakers, Installing and Removing 14.1) Release side panel from vehicle toward middle of car.
14.2) This panel will pull back allowing access to subwoofer enclosure.
How to Remove Speakers, Replace and Install 15.1) Disconnect connector at left side of amplifier.
15.2) Remove bolts securing subwoofer enclosure to side of vehicle.
   
Ford Car Audio - Wire Diagrams - Wire Color Codes
Factory Wire Harness Codes

Car Stereo Repair | Car Stereo Removal | FAQ | Shipping for Repair | Contact Us

   
DO NOT CUT FACTORY WIRE HARNESS
   
Aftermarket stereo installation? Why purchase the aftermarket wire harness? Installation is easier, no guess work with wire color codes and a Headache Saver! Factory wire colors codes are not universal. See Aftermarket Videos above.
We discourage cutting the factory wire harness.
This section aids in troubleshooting and determining wire color codes, phasing for speaker hook up, locating power wires for installing external devices and add-ons.
 
Diagram 1
Ford Wire Color Codes and Diagrams
   
Diagram 2
Ford Wire Color Codes and Diagrams
   
Diagram 3
Ford Wire Color Codes and Diagrams
   
Diagrams NOT ACCURATE for 100% of vehicles.
   

Car Stereo Repair | Car Stereo Removal | FAQ | Shipping for Repair | Contact Us

Factory Car Stereo Repair, Inc.
1987 Corporate Square, Suite 159
Longwood, Fl. 32750